<div>Hello all,</div><div><br></div>Here are some reasons why biogas is pretty safe and flashback is unlikely:<div><br></div><div>-Flashback generally only occurs where there is an oxygen feed at the site of the flashback. The most common example is the oxy-acetylene welder, where the rubber acetylene hose is bound to the rubber oxygen hose. If the supply line to the welding torch gets too hot the acetylene can autoignite and melt through the oxygen hose. The result is a hot flame with a good supply of oxygen that develops a high flame speed as the hose burns away. Note that the strategy for tackling flashback is to first turn off oxygen, reducing the flame heat and velocity.</div>

<div><br></div><div>-Methane is very volatile and buoyant. This means that any leaks rapidly disperse and travel upwards fast, making ignition difficult. This is why relief valves on large nat gas supply lines often vent to atmosphere, even in residential areas (for example pressure step down stations on the outskirts of cities).</div>

<div><br></div><div>-The contents of a digester and attached gas storage usually contains an extremely small fraction of oxygen. An ignition site within the digester probably isn't going to ignite the gas. An ignition site on the surface will, but the flame velocity will probably be relatively slow.</div>

<div><br></div><div>In summary, explosions are possible but unlikely. If you design your digester and storage vessel properly then you're probably safe. If you want to be extra cautious, bubble any gas lines through water. That should arrest any flashback.</div>

<div><br></div><div>Source: I'm a chemical engineering undergrad.</div><div><br></div><div>Will</div><div>Chemical Engineering/Science IV, Sydney University</div><div><br></div><div><br><div class="gmail_quote">On 4 August 2012 03:40, David <span dir="ltr"><<a href="mailto:david@h4c.org" target="_blank">david@h4c.org</a>></span> wrote:<br>

<blockquote class="gmail_quote" style="margin:0 0 0 .8ex;border-left:1px #ccc solid;padding-left:1ex">
  
    
  
  <div bgcolor="#FFFFFF" text="#000000">
    <font face="Georgia"><br>
      <br>
      Mark,<br>
      <br>
    </font><div>
    <div>On 8/2/2012 3:29 PM, Mark Wells wrote:<br>
    </div>
    <blockquote type="cite">Hi folks,
      <br>
      I have been wondering if it is really possible to blow up a
      digester, has any one actually ever seen this happen?
      <br>
      There is very little info on the web about this subject except
      boring hype from flame and flashback arrestor manufactures.
      <br>
    </blockquote>
    <br></div>
    You have to be more specific. There are a modest number of reports
    from the 20s through, say, the 40s of catastrophic explosive
    accidents involving municipal digesters. (See copies of the
    venerable "Sewage Works Journal".) It is harder to find information
    about explosive failures of low-tech and smaller digesters, but some
    may argue that part of the reason there are so few reports is that
    these incidents are bound to affect few people, in areas where
    accidental death is not uncommon (i.e. it may not be newsworthy),
    and where such incidents might be reported by those who installed
    the digester(s), they have a vested interest in not so doing.... In
    any case, it seems to be a fairly rare consequence.<br>
    <br>
    In response to the most general interpretation of the question,
    then, yes: it is possible to blow up a digester.<span><font color="#888888"><br>
    <br>
    <br>
    <br>
    d.<br>
    <div>-- <br>
      <div style="font:Georgia"><span style="font-size:110%">David
          William House<br>
        </span>
        <div style="padding-left:3em;font-size:80%">"The Complete
          Biogas Handbook" <code><a href="http://www.completebiogas.com" target="_blank">www.completebiogas.com</a></code><br>
          <em>Vahid Biogas</em>, an alternative energy consultancy <code><a href="http://www.vahidbiogas.com" target="_blank">www.vahidbiogas.com</a><br>
            <br>
          </code></div>
        <code>
          <div style="padding-left:2em">"Make no search for water.    
              But find thirst,<br>
            And water from the very ground will burst."
            <div style="padding-left:2em;font-size:80%">(Rumi, a
              Persian mystic poet, quoted in <em>Delight of Hearts</em>,
              p. 77) <br>
              <br>
              <a href="http://bahai.us/" target="_blank">http://bahai.us/</a></div>
          </div>
        </code></div>
    </div>
  </font></span></div>

<br>_______________________________________________<br>
Digestion mailing list<br>
<br>
to Send a Message to the list, use the email address<br>
<a href="mailto:Digestion@bioenergylists.org" target="_blank">Digestion@bioenergylists.org</a><br>
<br>
to UNSUBSCRIBE or Change your List Settings use the web page<br>
<a href="http://lists.bioenergylists.org/mailman/listinfo/digestion_lists.bioenergylists.org" target="_blank">http://lists.bioenergylists.org/mailman/listinfo/digestion_lists.bioenergylists.org</a><br>
<br>
for more information about digestion, see<br>
Beginner's Guide to Biogas<br>
<a href="http://www.adelaide.edu.au/biogas/" target="_blank">http://www.adelaide.edu.au/biogas/</a><br>
and the Biogas Wiki <a href="http://biogas.wikispaces.com/" target="_blank">http://biogas.wikispaces.com/</a><br>
<br>
<br></blockquote></div><br></div>