<div dir="ltr"><div>Frank -<br></div><div><br></div><div>Whether the upper char is fouled by organics coming off of lower pyrolysis zone in a TLUD is a function of operating temperature, which is a function of draft. TLUDs with sufficient draft make some of the best char out there.</div>
<div><br></div><div><a href="http://www.wcponline.com/pdf/October2012Kearns.pdf">http://www.wcponline.com/pdf/October2012Kearns.pdf</a><br></div><div class="gmail_extra"><br></div><div class="gmail_extra">The trick is to keep the draft high enough, and thus the char bed hot enough, to not condense tars during the burn.</div>
<div class="gmail_extra"><br></div><div class="gmail_extra">We looked at herbicide uptake using pine pellet char from a 1-gal natural draft "Toucan". Char from the bottom layer had about 35% greater sorption capacity for herbicide than char taken from the top layer. We have not measured, but I would speculate this difference to decrease in a high-draft scenario.</div>
<div class="gmail_extra"><br></div><div class="gmail_extra">Josh</div><div class="gmail_extra"><br><br><div class="gmail_quote">On Mon, May 6, 2013 at 12:52 PM, Frank Shields <span dir="ltr"><<a href="mailto:frank@compostlab.com" target="_blank">frank@compostlab.com</a>></span> wrote:<br>
<blockquote class="gmail_quote" style="margin:0 0 0 .8ex;border-left:1px #ccc solid;padding-left:1ex">Dear Stovers,<br>
<br>
It seems that a TLUD would make poor quality biochar. There are only two hot<br>
spots. One is the flame front and the second the flame heating the pot. As<br>
the flame front migrates down through new biomass volatiles come off and hit<br>
cooler conditions above in the left over char where I would think<br>
condensation of organics would occur. This is good as a cleaner gas goes up<br>
to the secondary air to combust and heat the pot. But the char is left with<br>
tars. This could be better for used as charcoal for other cooking but would<br>
make very poor biochar for the garden - if this is what happens.<br>
<br>
Regards<br>
<br>
Frank<br>
<br>
<br>
Thanks<br>
<br>
Frank Shields<br>
<br>
BioChar Division<br>
Control Laboratories, Inc.<br>
42 Hangar Way<br>
Watsonville, CE  95076<br>
<br>
<a href="tel:%28831%29%20724-5422" value="+18317245422">(831) 724-5422</a> tel<br>
(81) 724-3188 fax<br>
<a href="mailto:frank@biocharlab.com">frank@biocharlab.com</a><br>
<a href="http://www.controllabs.com" target="_blank">www.controllabs.com</a><br>
<br>
<br>
<br>
<br>
<br>
_______________________________________________<br>
Stoves mailing list<br>
<br>
to Send a Message to the list, use the email address<br>
<a href="mailto:stoves@lists.bioenergylists.org">stoves@lists.bioenergylists.org</a><br>
<br>
to UNSUBSCRIBE or Change your List Settings use the web page<br>
<a href="http://lists.bioenergylists.org/mailman/listinfo/stoves_lists.bioenergylists.org" target="_blank">http://lists.bioenergylists.org/mailman/listinfo/stoves_lists.bioenergylists.org</a><br>
<br>
for more Biomass Cooking Stoves,  News and Information see our web site:<br>
<a href="http://stoves.bioenergylists.org/" target="_blank">http://stoves.bioenergylists.org/</a><br>
<br>
</blockquote></div><br><br clear="all"><div><br></div>-- <br>Josh Kearns<br>PhD Candidate, Environmental Engineering<br>University of Colorado-Boulder<div>Visiting Researcher, North Carolina State University</div><div><br>
<div>Director of Science</div><div>Aqueous Solutions </div><div><a href="http://www.aqsolutions.org" target="_blank">www.aqsolutions.org</a></div><div><br></div><div>Mobile: 720 989 3959<br>Skype: joshkearns<br><br><br><br>
</div></div>
</div></div>