[Greenbuilding] finding coils inside (new) chest freezer
Frank Tettemer
frank at livingsol.com
Sun Dec 5 17:02:00 CST 2010
Frozen greetings, Reuben, from the out-back of Ontario.
If you have DC power available, (off grid, with batteries, or a reliable
converter), you have a variety of means for an efficient chest freezer.
If you are shopping for Brand New then:
Sundanzer, made by electrolux, Very good efficiency, and well insulated.
The least initial expense, for good energy efficiency.
However, two neighbours have used the "kits" made at the E-Z Kold shop
in Ontario, Canada.
They use stainless steel cold plates for inside of the insulation, (one
at either end works well),
and air-to-refrigerant heat exchange through a Danfoss compressor (12vdc
or 24vdc) on the outside.
(Danfoss is the same compressor used in the upright fridge and freezers
made by Sunfrost, Calif.
Danfoss is also used in the Sundanzer, and in other DC refrigeration
systems.)
If a person bought a used/dead freezer, about ten cubic feet, and lined
it with another 3" of polystyrene, then lined it with fiberglass &
resin, or,
aluminum flat stock, and placed two of the E-Z Kold cold plates in
either end, then they would have about 5 1/2 cubic feet of freezer
space. super well insulated, and run by the most efficient small
compressors in the business.
One of our neighbours re-insulated an existing older, large-size chest
freezer, and simply ran two runs of tubing to the colder basement, and
had the compressor and air cooling tubes down there, working most
efficiently, close to the battery room, and in a naturally cool area.
We are off-grid, thus considering each and every detail. We have about
six cubic feet of freezer space, outside. We have about four and a half
feet of freezer space, sort-of indoors, and ten feet of fridge, partly
indoors, all running off the house battery bank.
Our outdoor freezer is run by a Danfoss compressor, and is located in an
un-heated entry mud room. From now until spring, it very rarely runs.
We hear a compressor-run-cycle, for five minute duration, sometimes
more than three or four days between run cycles. It's just sipping from
the battery bank, during our season of the least photovoltaic
opportunities. i.e., it's cloudy now, until mid-winter. Good timing for
us.
Our in-house Fridge/Freezer is a Sunfrost, with the entire cabinet front
built flush with the interior wall, and projecting outward from the
house walls, and surrounded by out-door ambiant air temperatures. We
rarely hear the fridge or the freezer run at all, from now until Spring
time.
To buy one ready to go:
http://www.sundanzer.com/Home.html
They make one model that I can heartily reccomend, from many neighbour's
use experiences, with about 5 1/2 cubic feet of space.
Or to build one from scratch, or re-convert an existing shell:
http://www.e-zkold.com/conversion.htm
the model of kit best suited for about half dozen cubic feet of freezer is:
*EK-12CPA**-2 **Air Cooled 12 Volt Twin Cold Plate System*
Cheers,
Frank
--
Frank Tettemer
Living Sol ~ Building and Design
www.livingsol.com
613 756 3884
More information about the Greenbuilding
mailing list