[Gasification] mycoremediation of tarry water

Fri Feb 1 15:29:02 CST 2013

For very small use, like a single home, IC engines are inexpensive and
widely available.  Steam equipment for this size is not readily available to
the same degree.

Dan

From: Gasification [mailto:gasification-bounces at lists.bioenergylists.org] On
Behalf Of stuart mather
Sent: Thursday, January 31, 2013 9:08 PM
To: stuart mather; Discussion of biomass pyrolysis and gasification
Subject: Re: [Gasification] mycoremediation of tarry water

Ok, steam turbines under 250 hp aren't efficient and a turbine needs super
heated steam. But a reciprocating steam engine is efficient and doesn't need
superheated steam, so aren't these better than trying to deal with tar in an
internal combustion engine?

Stuart.

  _____  

From: stuart mather <kneebraceboy at yahoo.com.au>
To: Discussion of biomass pyrolysis and gasification
<gasification at lists.bioenergylists.org> 
Sent: Friday, 1 February 2013 12:21 PM
Subject: Re: [Gasification] mycoremediation of tarry water

I'm just curious why syngas is ever deliberately burnt in an internal
combustion engine in a deliberate setup when surely it would completely
sidestep the tar/acids corrosion/disposal issue if the heat was just used to
power a steam turbine driven generator? Sorry if it's a daft question.

Stuart.

  _____  

From: Robert Fairchild <solarbobky at yahoo.com>
To: Discussion of biomass pyrolysis and gasification
<gasification at lists.bioenergylists.org> 
Sent: Friday, 1 February 2013 11:40 AM
Subject: Re: [Gasification] mycoremediation of tarry water

This might be a job for mushrooms. Really. Filter the water through straw or
woodchips then innoculate with the appropriate fungus. It's known as
mycoremediation. Paul Stamets is the expert.
See:
http://www.realitysandwich.com/mycoremediation_and_oil_spills
http://www.wsdot.wa.gov/research/reports/fullreports/464.1.pdf
 Bob

--- On Thu, 1/31/13, linvent at aol.com <linvent at aol.com> wrote:

From: linvent at aol.com <linvent at aol.com>
Subject: Re: [Gasification] Gasification Digest, Vol 29, Issue 7: scrubber
water
To: gasification at lists.bioenergylists.org
Date: Thursday, January 31, 2013, 8:15 PM

And some of the gasifiers in India simply dump it in ponds. One very well
funded group set up large tanks ala biodigesters, that didn't work. This is
the same group that spent $200 mm on an Australian  MSW to power gasifier
that was scrapped.  It is not acceptable to dump the produced water in any
normal waste water treatment system. Even in "clean" gasifier gas the
moisture content going to the engine will bring organic acids and other
compounds that will reduce the lifetime and the power output of the engine.
There are effective water treatment systems available, and after years of
trying a variety of options, we have landed on ones that work well and are
relatively inexpensive to construct and operate. If you look at the cost of
a coal gasifier water treatment plant, it is a significant investment.

Sincerely,

Leland T. "Tom" Taylor

Thermogenics Inc. 

-----Original Message-----
From: David Coote <dccoote at mira.net>
To: gasification <gasification at lists.bioenergylists.org>
Sent: Thu, Jan 31, 2013 5:38 pm
Subject: Re: [Gasification] Gasification Digest, Vol 29, Issue 7: scrubber
water

How were they handling the scrubber water, Tom? A colleague visited a 
reasonable size gasifier in Europe where the water was stored in a tank. 
Once this tank was full their immediate option was to install another 
tank. Not ideal!

Waste disposal is becoming increasingly expensive in Australia. This 
would increase the cost of the power.

Regards

David

On 1/02/2013 7:00 AM, gasification-request at lists.bioenergylists.org wrote:
> ------------------------------ Message: 20 Date: Thu, 31 Jan 2013 
> 09:32:11 -0800 From: "Tom Miles" <tmiles at trmiles.com> To: "'Discussion 
> of biomass pyrolysis and gasification'" 
> <gasification at lists.bioenergylists.org> Subject: Re: [Gasification] 
> Power Pallet Message-ID: <00f201cdffd8$e7c8ae80$b75a0b80$@trmiles.com> 
> Content-Type: text/plain; charset="us-ascii"
>> >yes, but remember that all that run these fuels to date are doing so by
>>      
> tolerating a dirty gas non tar solving reactor, and fighting the tar
problem
> in the filtering.  on the low tech end this is nearly always a water
> scrubbing system, which really just>moves the toxic problem somewhere
else,
> and actual real world running is highly unattractive.  yes, it will work
for
> the demo, but the ongoing issues with the bongwater cofferdam challenges
> health, regulatory and general pleasurable>concerns.
> 
> Not so fast. You can't write off "tar making" gasifiers completely. While
> your observation may be true for hundreds of low cost gasifiers now in
use,
> in the last five years I have seen three small scale gas cleaning systems
> using wet scrubbers that would pass California air quality and safety
> regulations. One is produced commercially and was demonstrated at the 300
> kWe scale. Another was demonstrated at 300 KWe and used on a 1 MWe system.
> One was demonstrated on a 100 kWe downdraft gasifier generating 100 kWe
from
> grass seed screenings. I know of another two in development for the 40 kWe
> scale. (I also know of at least one that has failed miserably.)
> 
> Tar making gasifiers may be a solution for some very difficult but
abundant
> fuel like rice husks and agricultural residues if the tars can be managed
> and destroyed acceptably.
> 
> Tom
>    

_______________________________________________
Gasification mailing list

to Send a Message to the list, use the email address
Gasification at bioenergylists.org

to UNSUBSCRIBE or Change your List Settings use the web page
http://lists.bioenergylists.org/mailman/listinfo/gasification_lists.bioenerg
ylists.org

for more Gasifiers,  News and Information see our web site:
http://gasifiers.bioenergylists.org/

-----Inline Attachment Follows-----

_______________________________________________
Gasification mailing list

to Send a Message to the list, use the email address
Gasification at bioenergylists.org

to UNSUBSCRIBE or Change your List Settings use the web page
http://lists.bioenergylists.org/mailman/listinfo/gasification_lists.bioenerg
ylists.org

for more Gasifiers,  News and Information see our web site:
http://gasifiers.bioenergylists.org/

_______________________________________________
Gasification mailing list

to Send a Message to the list, use the email address
Gasification at bioenergylists.org

to UNSUBSCRIBE or Change your List Settings use the web page
http://lists.bioenergylists.org/mailman/listinfo/gasification_lists.bioenerg
ylists.org

for more Gasifiers,  News and Information see our web site:
http://gasifiers.bioenergylists.org/

_______________________________________________
Gasification mailing list

to Send a Message to the list, use the email address
Gasification at bioenergylists.org

to UNSUBSCRIBE or Change your List Settings use the web page
http://lists.bioenergylists.org/mailman/listinfo/gasification_lists.bioenerg
ylists.org

for more Gasifiers,  News and Information see our web site:
http://gasifiers.bioenergylists.org/

-------------- next part --------------
An HTML attachment was scrubbed...
URL: <http://lists.bioenergylists.org/pipermail/gasification_lists.bioenergylists.org/attachments/20130201/2a6005d7/attachment.html>